High Solid Content Copper Ore Flotation

  • pH Control in Copper Flotation Application Note for ...

    The copper flotation process Crushed ore, along with water and lime slurry, is fed into a ball mill. This rotating drum contains steel balls that crush the ore to a fine powder. When the ore/lime slurry emerges from the mill, it is fed to a rake classifier. Particles that are too large to pass from the classifier are returned to the mill, while the overflow is discharged to flotation cells ...

    Get Price
  • Copper Mining and Extraction Sulfide Ores

    Place these products in the extraction process in ascending order of copper content. Use the flow chart as a guide: Matte Ore Cathode copper Blister Anode copper Copper concentrate Fire refined copper; Use a periodic table to find the atomic masses of the elements in cuprite and chalcocite. Then work out the percentage of copper in each mineral ...

    Get Price
  • Process mineralogical characterization of Kansanshi copper ...

    high degree of liberation of chalcopyrite associated with the overall coarse texture of the sulphide ore. Mineralogical investigations suggest that the relatively low copper grades from batch flotation cannot be attributed to the presence of composite particles, and can potentially be improved using a …

    Get Price
  • Selectivity and power of frothers in copper ore flotation

    content of copper in the feed was 0.78±0.2%. Selectivity and power of frothers in copper ore flotation 517 The ore was crushed in a jaw crusher to obtain particles smaller than 1 mm in size. Prior to each flotation experiment, the crushed material was wet ground in a steel ball mill. The size distribution of the ore, used as the flotation feed, is presented in Table 1. Table 1. Feed size ...

    Get Price
  • Flotation of Copper Sulfide Ores - PDF Free …

    ash and NaOH are suitable for low-pyrite copper–gold ores, but not for copper–gold ores with high pyrite content. Ore with high pyrite content requires higher lime additions for pyrite depression and sometimes NaCN is also used. This flotation is not favorable for gold, as both cyanide and high lime have negative effects on gold recovery ...

    Get Price
  • Recovery Cu from a Copper Oxide Ore by …

    The copper oxide ore is high oxidation ratio and the high combination ratio with a low grade of Cu 0.71%. Copper concentrate of Cu 15.02% with a recovery of 38.55% was obtained by flotation. The optimum acid leaching conditions were investigated. Effects of lixiviant concentration, solid-to-liquid ratio, leaching time were investigated. The acid leaching efficiency was 78.75% relative to ...

    Get Price
  • Copper–molybdenum ores flotation in sea water ...

    01.11.2013· Subsequently, frothing experiments were conducted with the same copper ores and flotation conditions, modifying the flotation cell and applying a digital photographical method coupled to image analysis. Froth layer thickness and mass of water transferred to the froth volume were measured as a function of pH and solids content, with sea water and fresh water. 2.1. Materials 2.1.1. Samples ...

    Get Price
  • Copper–molybdenum ores flotation in sea water ...

    01.11.2013· Subsequently, frothing experiments were conducted with the same copper ores and flotation conditions, modifying the flotation cell and applying a digital photographical method coupled to image analysis. Froth layer thickness and mass of water transferred to the froth volume were measured as a function of pH and solids content, with sea water and fresh water. 2.1. Materials 2.1.1. Samples ...

    Get Price
  • sizing plant copper ore flotation - doitbetter.es

    recovery of copper from oxide copper ore by flotation ... - METU. 2 Dec 2014 ... flotation and agitating sulphuric acid H2SO4 leaching. ... grind size of copper minerals was determined as 75 microns after examination ... years in the past at one of the Soviet plants 1% copper containing oxide copper ore.

    Get Price
  • Optimization of the flotation of copper smelter slags from ...

    discarded due to the high content of copper and hence they are sent to a milling and flotation plant (Slag Mill Plant) for liberation and recovery of copper. This work focuses on optimizing the recovery of copper minerals in copper smelter slags by means of froth flotation. Most of the copper minerals present in the Namibia Custom Smelters' slags are free sulphide minerals, however a certain ...

    Get Price
  • RECOVERY OF COPPER FROM OXIDE COPPER ORE BY FLOTATION …

    RECOVERY OF COPPER FROM OXIDE COPPER ORE BY FLOTATION AND LEACHING Kiraz, Emirhan M.S., Department of Mining Engineering Supervisor: Prof. Dr. Mustafa Ümit Atalay December 2014, 65 pages The aim of this study was the recovery of copper from the oxide copper ore by froth flotation and agitating sulphuric acid (H 2 SO 4) leaching. The ore with 4.21% copper grade used in …

    Get Price
  • pH/ORP measurement Copper flotation process

    A high pH is important in copper ore processing to maximize this mineral's flotation properties. Most copper ore slurries tend to be acidic. Plants typically add lime to the slurry in the mill or floatation circuit, increasing its alkalinity. A typical copper operation contains many flotation cells, often with a …

    Get Price
  • Multidimensional Analysis of Copper Ore …

    Flotation is a method of enrichment used to distribute particles, which differ in their surface properties. Hydrophobic solids intrinsically create contact at the solid-liquid-gas interface. However, not all minerals, including copper minerals, can be characterized by this crucial ability. In that case it is necessary to use the collector reagents which guarantees a high efficiency of the ...

    Get Price
  • Recovery of Copper from a High Content of …

    The study aims to recover copper minerals from a high content of slime and refractory copper oxide ore by flotation process. Based on the research on the properties of the material, the grinding fineness and reagent system are investigated and a technological flow sheet consisting of one roughing flotation, two concentrate flotation, three scavenging flotation and one concentrate-scavenging ...

    Get Price
  • RECOVERY OF COPPER FROM OXIDE COPPER ORE BY FLOTATION …

    Results of flotation tests were unsuccessful in terms of both recovery and grade of concentrate product. The highest copper recovery of concentrate was found as 61.35% with 8.69% copper content. The concentrate with highest copper grade of 34.65% was obtained with only 26.98% copper recovery.

    Get Price
  • Estimated Water Requirements for the Conventional ...

    Flotation of Copper Ores . By Donald I. Bleiwas . Introduction . This report provides a perspective on the amount of water used by a conventional copper flotation plant, including the makeup water required to compensate for water losses. Much of the global supply of copper originates from mines that also produce byproduct molybdenum, but for simplicity, a single copper concentrate has been ...

    Get Price
  • Copper Ore - an overview | ScienceDirect Topics

    Flotation entails first attaching fine copper mineral particles to bubbles rising through an ore–water pulp and, second, collecting the copper minerals at the top of the pulp as a briefly stable mineral–water–air froth. Noncopper minerals do not attach to the rising bubbles; they are discarded as "tailings." The selectivity of the process is controlled by chemical reagents added to ...

    Get Price
  • Copper Ore Processing Flotation Machine …

    Hot Copper Ore Flotation Machine In Indonesia The copper ore flotation machine was created for mineral processing by flotation The flotation machine is usually used within a pulp flotation method in a wide selection of solid parts concentration at the same time as for enrichment of minerals of high certain Gold Flotation Machine In Indonesia.

    Get Price
  • The Effect of Oxidation on the Flotation Behaviour of ...

    followed by copper sulphate addition to facilitate the activation and flotation of remaining pyrrhotite and other sulphides. As may be noted from Figure I, the flotation rates of chalcopyrite and pentlandite are much higher than that of pyrrhotite. Thus, with its marginal pyrrhotite content, the primary rougher

    Get Price
  • Copper Mining and Extraction Sulfide Ores

    Place these products in the extraction process in ascending order of copper content. Use the flow chart as a guide: Matte Ore Cathode copper Blister Anode copper Copper concentrate Fire refined copper; Use a periodic table to find the atomic masses of the elements in cuprite and chalcocite. Then work out the percentage of copper in each mineral ...

    Get Price
  • Selectivity and power of frothers in copper ore flotation

    content of copper in the feed was 0.78±0.2%. Selectivity and power of frothers in copper ore flotation 517 The ore was crushed in a jaw crusher to obtain particles smaller than 1 mm in size. Prior to each flotation experiment, the crushed material was wet ground in a steel ball mill. The size distribution of the ore, used as the flotation feed, is presented in Table 1. Table 1. Feed size ...

    Get Price
  • A study of the flotation characteristics of a complex ...

    copper (ASCu) content of the ore, which is used as a proxy for oxide mineral content. An important finding in this study was that sulphide minerals are also prone to digestion during this analysis. Chalcopyrite was the major copper mineral in the HQ ore, constituting 3.9 %, but only 1.0 % of the LQ ore. LQ ore was dominated by chrysocolla, which constituted 3.8 % of the ore. The treatment of ...

    Get Price
  • Copper Flotation - Mineral Processing & Metallurgy

    Metallurgical ContentA Copper Flotation FlowsheetCOPPER MININGCRUSHING COPPER ORECOPPER ORE STORAGEGRINDING COPPER ORECOPPER FLOTATION CIRCUITCOPPER THICKENING AND FILTERINGPROCESS CONTROLSCopper Flotation Process SummaryFlotation of Copper Ores Although basic porphyry copper flotation and metallurgy has remained virtually the …

    Get Price
  • A study of the flotation characteristics of a complex ...

    copper (ASCu) content of the ore, which is used as a proxy for oxide mineral content. An important finding in this study was that sulphide minerals are also prone to digestion during this analysis. Chalcopyrite was the major copper mineral in the HQ ore, constituting 3.9 %, but only 1.0 % of the LQ ore. LQ ore was dominated by chrysocolla, which constituted 3.8 % of the ore. The treatment of ...

    Get Price

Related Posts